New sulfuric acid application reduces ammonia emissions by 40% Article-New sulfuric acid application reduces ammonia emissions by 40% Veronika Overmeyer / University of Bonn

Apr 10, 2023

A study by the University of Bonn shows a retrofit solution for existing barn systems can reduce ammonia emissions by around 40% just inside the barn. It also reduces the production of methane even more significantly, which could be an important contribution to the fight against climate change. The results will be published in the Journal of Environmental Management, but are already available online.

The European Union imposes national ammonia emission limits on its member states, but the question remains how these can be achieved without farmers having to carry out extremely costly new constructions or conversions of their livestock buildings?

"Over the past three years, we have been testing a technology that can be used to retrofit existing barns," explains Veronika Overmeyer of the Institute for Agricultural Engineering at the University of Bonn.

Together with their project partners, the companies SF-Soepenberg and Hölscher + Leuschner, the researchers used a tried-and-tested method for this purpose: the acidification of slurry with sulfuric acid. Pigs and cattle are often kept on so-called slatted floors. Their excrements fall through slits in the floor into the slurry channel below. There they are stored until they are used as fertilizer at the beginning of the next growing season.

"Ammonia is continuously released from the fecal-urine mixture," Overmeyer says. "Adding acid causes ammonia to be present as ammonium, which cannot escape in a gaseous form and thus remains in the slurry." This mechanism has been known for a long time. In Germany, for example, acid is already added to some of the slurry when it is spread on the fields. However, this does not control the outgassing that occurs in the barn or during slurry storage.

Acidifying the excrements directly in the slurry channel can be dangerous under certain circumstances, as toxic hydrogen sulfide can be produced. "This is why we moved this process out of the barn," Overmeyer emphasizes. "Every few days, we pump the slurry into a special agitation tank where it is mixed with sulfuric acid. The freshly acidified slurry is then pumped back into the slurry channel."

This means it can continue to be stored in the barn, while at the same time reducing ammonia emissions. These fell by just under 40% in the study. If the method is optimized, values of even more than 60% are conceivable. Ammonia emissions from fertilization with the pre-treated slurry are also significantly lower. In addition, because the acidified slurry contains higher amounts of nitrogen and sulfur than normal, it has an even better fertilizing effect.

Another observation was also unexpected: Acidification also suppressed the formation of methane. "Our method enabled us to reduce methane emissions by two-thirds," explains Professor Wolfgang Büscher from the ILT, who supervised the study. "So we're killing two birds with one stone."

The retrofit does not come for free. However, it is comparatively inexpensive compared to costly conversions or even new construction, with additional benefits for the farmer in the form of improved fertilization. Nevertheless, the solution currently falters on account of the German legislative situation. This stipulates that the addition of acid to stored slurry is only permitted if the slurry channel has previously been sealed with special liner.

"That makes the retrofit much more expensive," Overmeyer says. "Yet studies show that this measure is not necessary, because despite the slightly lower pH in the slurry, the walls of the slurry channels do not wear significantly faster."

Her hopes are now pinned on a new draft bill that proposes to abolish the statutory sealing requirement. However, this has been on the table for years and has not yet been passed into law. "I find this somewhat annoying," Overmeyer says: "On the one hand, we expect farmers to be more environmentally friendly, and on the other hand, we put obstacles in their way."

For her study, she spent a year and a half comparing two fattening pig barns (with and without slurry acidification) at the Faculty of Agriculture's Teaching and Research Station. "Long-term studies of this kind are a rarity, because they are so costly," emphasizes her doctoral supervisor Büscher. "With the Frankenforst campus, we have one of the few facilities in this country where this is even possible."

In addition to the University of Bonn, the study involved SF-Soepenberg GmbH in Hünxe and Hölscher + Leuschner GmbH & Co. KG in Emsbüren. 

Source : National Hog farmer
Subscribe to our Newsletters

Trending Video